Golf Carts on Ground

Top 5 Common Issues with Golf Carts and How to Fix Them

Last updated on November 2nd, 2022 at 12:02 am

5/5 - (1 vote)

Let’s face it, golf carts aren’t the most complex of vehicles. However, that doesn’t mean they don’t have their fair share of issues. There are several common problems with golf carts and how to fix them.

Thank you for reading this post, don't forget to subscribe!

They might seem minor but can ruin a player’s round in no time at all. Luckily for you, we know everything there is to know about fixing these pesky little problems with your trusty golfer friend.

Fortunately, the solutions to these issues are pretty straightforward and easy to address; especially if you read this article! We’ll go through some of the top issues with golf carts and how to fix them so that your next round will be problem-free. So let’s get started…

Jump Starts Are Hard to Come By

If you have a flat battery in your golf cart, you might be thinking that your only option is to get a jump start like you would any other car. But unfortunately, that might not be the case.

Typically, you would use jumper cables to transfer enough current from the good battery to start the car with a dead battery. You would just need to put one end of the cable on the good battery, and the other end on the bad battery, and you’re good to go. However, golf carts are a little different.

The batteries in golf carts are hard to access, which makes jump starters almost useless. Not to mention that the voltages on the batteries are pretty high.

That means you’d need to get extremely close to the batteries with a pair of jump leads, which is potentially very dangerous. So in general, golf cart batteries are very difficult to jump-start and are best charged using a charger instead.

Golf Carts Overheat and Over-Rev

If the voltage in your battery drops too low (less than 10 volts), the engine may start to overheat. If it gets really low, it may even shut down the engine altogether. On the other hand, if your battery is overcharged, the engine may over-rev.

Typically, the engine will let you know if these issues are present by emitting a series of tones and flashing lights. If you’re not sure what the sounds mean, check your owner’s manual for more information.

While it’s unlikely that the battery will overheat, it’s possible that the engine is overheating due to a low voltage. Finding out why the voltage is low can be tricky, but one of the most likely causes is that there is excessive moisture inside the battery or the terminals are corroded.

To solve this problem, you will need to clean the terminals and/or remove the battery and blow out the terminals with compressed air. If you don’t do this, the low voltage may be a symptom of a bigger problem.

Batteries Die Quickly

Batteries die after a while, that’s just the nature of the beast. However, you can expect the batteries in your golf cart to last around 10 years if you maintain them properly.

If you’re noticing that the batteries are dying more quickly than usual, there are a few potential causes. Firstly, the batteries might be old and need to be replaced.

However, there could also be something wrong with the charging system or the charging connections. The charging connections are the terminals that attach the batteries to the charger.

If the terminals are corroded or dirty, there might not be a proper connection between the charger and the batteries, which often means the batteries won’t charge properly.

The Shifting Issue

If you’ve ever driven a car, you’ve probably noticed how it occasionally skips gears when you shift. Golf carts are no different. If you notice your golf cart skipping gears, the cause is likely to be a loose connection or a weak spring in the transmission.

There are a few ways to fix this problem. Firstly, you can clean the connections, but if the problem persists, the transmission may need to be adjusted or replaced.

GPS and Communication Problems

GPS devices and golf carts have been best friends for a long time. However, as we move into a more technologically advanced world, there are still a number of issues present that keep these two from being inseparable.

That being said, there are a few common issues that golf cart owners experience with GPS devices, and we’ll tell you how to solve them. First off, you may notice a delay between the time you press the button on your GPS device to the time it actually happens on the golf course.

This typically occurs when you’re using a satellite signal instead of a cellular signal. The good news is that there is a simple solution. To increase the speed of your GPS device, you’ll need to change the settings to Cellular instead of Satellite.

Conclusion

Golf carts aren’t the most complex of machines, but they do have their fair share of issues. Fortunately, they’re easy to fix and are often fairly easy to avoid. If you’re looking to avoid these issues during a round, you should always keep the following things in mind…

Be sure to charge your batteries every few days, check the connections every once in a while, and clean the terminals occasionally. That way, your golf cart will be in tip-top shape for years to come, so you can keep taking smooth, seamless golf cart rides with your buddies!

FAQ

What Is the Life Expectancy of a Golf Cart?

The life expectancy of a golf cart depends on a number of factors, including how often it is used and how well it is maintained. Generally, golf carts have a life expectancy of 20 to 40 years.

Do All Golf Cart Motors Have a Reset Button?

No, all golf cart motors do not have a reset button. Depending on the model of the golf cart, there may be a reset button located on the motor itself or on the controller. If your golf cart does not have a reset button, you may need to take it to a qualified repair shop.

Similar Posts

Leave a Reply

Your email address will not be published. Required fields are marked *

This site uses Akismet to reduce spam. Learn how your comment data is processed.